Product ID:MT TONER, RP609Z
MSDS Date:03/05/1992
FSC:6850
NIIN:00N061663
MSDS Number: BYBCB

MINOLTA CORP

101 WILLIAMS DRIVE
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER (2 KINDS)

CAS: 25153-46-2

Fraction By Weight: >85%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5-10%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-0

RTECS: TR5000000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MIN RESP TRACT IRRIT MAY OCCUR
AS W/EXPOS TO LG AMTS OF ANY NONTOX DUST. MAY CAUSE COUGH & RAISE
PHLEGM. TONER PRESENTS LOW HAZ FOR USUAL OCCUP SETTINGS. BASED ON
AVAIL DATA, HUMAN EXPOS TO TONE R HAS BEEN SHOWN TO CAUSE MIN RESP
TRACT IRRIT AS MAY OCCUR W/LG AMTS OF ANY NON-TOX DUSTS. RSLTS OF
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:ONE ANIMAL STUDY WHERE RATS INHALED
TONER THAT WAS 10 TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAIL
TONER WERE OBSERVED TO HAVE NO LUNG CHANGES AT LOW EXPOS. AT HIGHER
LEVELS SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO
EXCESSIVE AMTS OF DUST RETAINED IN LUNGS FOR A PRLNG INTERVAL.
CHRONIC:NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES:FLUSH W/WATER FOR AT
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED WHEN USED AS INTENDED IN
MINOLTA EQUIPMENT.
Protective Gloves:NONE REQD WHEN USED AS INTENDED (SUPDAT)
Eye Protection:NONE REQD WHEN USED AS INTENDED (SUPDAT)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
PROT GLOVES:IN MINOLTA EQUIPMENT. EYE PROT:IN MINOLTA EQUIPMENT.

Spec Gravity:1.2 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.